TiO2光催化降解H2S的利用率研究

赵士奇;王磊;王东辉;金君素

北京化工大学学报(自然科学版) ›› 2015, Vol. 42 ›› Issue (2) : 13-18.

PDF(1744 KB)
欢迎访问北京化工大学学报(自然科学版),今天是 2025年5月8日 星期四
Email Alert  RSS
PDF(1744 KB)
北京化工大学学报(自然科学版) ›› 2015, Vol. 42 ›› Issue (2) : 13-18.
化学与化学工程

TiO2光催化降解H2S的利用率研究

  • 赵士奇;王磊;王东辉;金君素
作者信息 +

Variation of TiO2 utilization ratio in H2S photocatalytic degradation

  • ZHAO ShiQi;WANG Lei;WANG DongHui;JIN JunSu
Author information +
文章历史 +

摘要

采用孔径48μm不锈钢网负载TiO2薄膜作为光催化材料,以低功率紫外灯作为光源,在连续性反应器内降解H2S。首先探讨了气体含氧量对H2S光催化氧化产物和TiO2利用率的影响,之后分析了H2S体积分数、光照面积以及TiO2用量等因素对TiO2利用率和失活速率的影响。结果表明,当反应气中氧含量从0升高至1.0%时,H2S的主要氧化产物由单质硫变成SO2或SO2-4,催化剂利用率先升高后降低,氧和H2S的投入量之比n(O2)∶n(H2S)约为50∶1时TiO2的利用率最高;降低H2S的初始体积分数或增大TiO2的负载面积均可减缓催化剂失活,提高TiO2利用率;不锈钢网面积为168cm2时,催化剂的最佳负载量为0.35g左右。

Abstract

H2S was degraded in a continuous photocatalytic reactor, using low-powered UV-light as an optical source, and a TiO2 film loaded on a stainless steel network as a photocatalyst. The influence of O2 concentration on photocatalytic oxidation products of H2S was first studied. The results showed that H2S is oxidized to ulfur in the absence of O2, but when the content of O2 was increased to 1%, SO2 and SO2-4 were the major products. The photocatalytic activity of the TiO2 film is reduced by both S and SO2-4 deposition, leading to the incomplete removal of H2S. Further studies of the inactivation rate and utilization ratio of the TiO2 film were carried out. The optimum proportion of H2S to O2 was found to be about 1∶50 under the experimental conditions, and the TiO2 utilization ratio can be increased by decreasing the H2S content or increasing the irradiation area. When the stainless steel network area was 168cm2, the optimum dosage of the TiO2 film was about 0.35g.

引用本文

导出引用
赵士奇;王磊;王东辉;金君素. TiO2光催化降解H2S的利用率研究[J]. 北京化工大学学报(自然科学版), 2015, 42(2): 13-18
ZHAO ShiQi;WANG Lei;WANG DongHui;JIN JunSu. Variation of TiO2 utilization ratio in H2S photocatalytic degradation[J]. Journal of Beijing University of Chemical Technology, 2015, 42(2): 13-18

参考文献

[1]Ma G, Yan H, Shi J, et al. Direct splitting of H2S into H2 and S on CdS-based photocatalyst under visible light irradiation[J]. Journal of Catalysis, 2008, 260(1): 134-140. 
[2]马贵军, 鄢洪建, 宗旭, 等. 气-固相光催化分解H2S制氢[J]. 催化学报, 2008, 29(4): 313-315.
Ma G J, Yan H J, Zong X, et al. Photocatalytic splitting of H2S to produce hydrogen by gas-solid phase reaction[J]. Chinese Journal of Catalysis, 2008, 29(4): 313-315. (in Chinese)
[3]Jing D, Jing L, Liu H, et al. Photocatalytic hydrogen production from refinery gas over a fluidized-bed reactor II: parametric study[J]. Industrial & Engineering Chemistry Research, 2013, 52(5): 1992-1999. 
[4]Chaudhari N S, Bhirud A P, Sonawane R S, et al. Ecofriendly hydrogen production from abundant hydrogen sulfide using solar light-driven hierarchical nanostructured ZnIn2S4-photocatalyst[J]. Green Chemistry, 2011, 13(9): 2500-2506. [5]Chaudhari N S, Warule S S, Dhanmane S A, et al. Nanostructured N-doped TiO2 marigold flowers for an efficient solar hydrogen production from H2S[J]. Nanoscale, 2013, 5(19): 9383-9390. 
[6]Portela R, Tessinari R F, Suarez S, et al. Photocatalysis for continuous air purification in wastewater treatment plants: from lab to reality[J]. Environmental Science & Technology, 2012, 46(9): 5040-5048.
[7]Alonso-Tellez A, Masson R, Robert D, et al. Comparison of Hombikat UV100 and P25 TiO2 performance in gas-phase photocatalytic oxidation reactions[J]. Journal of Photochemistry and Photobiology A: Chemistry, 2012, 250: 58-65. 
[8]Yu Y, Zhang T, Zheng L, et al. Photocatalytic degradation of hydrogen sulfide using TiO2 film under microwave electrodeless discharge lamp irradiation[J]. Chemical Engineering Journal, 2013, 225: 9-15.
[9]Kato S, Hirano Y, Iwata M, et al. Photocatalytic degradation of gaseous sulfur compounds by silver-deposited titanium dioxide[J]. Applied Catalysis B: Environmental, 2005, 57(2): 109-115. 
[10]郭建辉, 金振声, 张敏, 等. TiO2光催化消除H2S的研究[J]. 感光科学与光化学, 2004, 22(3): 211-217. Guo J H, Jin Z S, Zhang M, et al. Photocatalytic-oxidation of H2S on TiO2[J]. Photographic Science and Photochemistry, 2004, 22(3): 211-217. (in Chinese)
[11]Li X, Zhang G, Pan H. Experimental study on ozone photolytic and photocatalytic degradation of H2S using continuous flow mode[J]. Journal of Hazardous Materials, 2012, 199: 255-261. 
[12]Portela R, Canela M C, Sánchez B, et al. H2S photodegradation by TiO2/M-MCM-41 (M=Cr or Ce): deactivation and by-product generation under UV-A and visible light[J]. Applied Catalysis B: Environmental, 2008, 84(3): 643-650. 
[13]Alonso-Tellez A, Robert D, Keller N, et al. A parametric study of the UV-A photocatalytic oxidation of H2S over TiO2[J]. Applied Catalysis B: Environmental, 2012, 115: 209-218. 
[14]Kataoka S, Lee E, Tejedor-Tejedor M I, et al. Photocatalytic degradation of hydrogen sulfide and in situ FT-IR analysis of reaction products on surface of TiO2[J]. Applied Catalysis B: Environmental, 2005, 61(1): 159-163. 
[15]Portela R, Suárez S, Rasmussen S B, et al. Photocatalytic-based strategies for H2S elimination[J]. Catalysis Today, 2010, 151(1): 64-70. 
[16]Rasmussen S B, Portela R, Suárez S, et al. Hybrid TiO2-SiMgOX composite for combined chemisorption and photocatalytic elimination of gaseous H2S[J]. Industrial & Engineering Chemistry Research, 2010, 49(15): 6685-6690. 
[17]杨庆, 郭奋, 邢颖, 等. TiO2多孔性薄膜光催化降解低浓度甲醛[J]. 环境科学, 2005, 26(4): 35-39.Yang Q, Guo F, Xing Y, et al. Photocatalytic degradation of low level formaldehyde on TiO2 porous film[J]. Environmental Science, 2005, 26(4): 35-39. (in Chinese)

PDF(1744 KB)

1412

Accesses

0

Citation

Detail

段落导航
相关文章

/