基于局域波分解的循环射流混合槽内压力脉动信号时频特性分析

禹言芳;吴剑华;孟辉波*

北京化工大学学报(自然科学版) ›› 2012, Vol. 39 ›› Issue (6) : 23-30.

PDF(1663 KB)
欢迎访问北京化工大学学报(自然科学版),今天是 2025年7月11日 星期五
Email Alert  RSS
PDF(1663 KB)
北京化工大学学报(自然科学版) ›› 2012, Vol. 39 ›› Issue (6) : 23-30.
化学与化学工程

基于局域波分解的循环射流混合槽内压力脉动信号时频特性分析

  • 禹言芳;吴剑华;孟辉波*
作者信息 +

Analysis of the time-frequency attributes of pressure fluctuation signals in a circulating jet tank based on local wave decomposition

  • YU YanFang;WU JianHua;MENG HuiBo
Author information +
文章历史 +

摘要

为了探讨循环射流混合槽射流混合区内瞬态流动特性,在Re=3660~32940范围内利用动态数据采集系统对射流混合区内不同轴向、径向和周向位置的瞬态脉动压力进行了测量,并采用基于局域波分解的方法分析了循环射流混合槽内压力脉动信号的时频分布。研究表明:瞬态压力波动信号的波动能量分布随瞬时频率的提高明显降低;在θm=π/6和π/3时,频率集中分布在为0~0.25Hz,而θm=π/4和θm=5π/12时,瞬时波动频率主要分布在0~6Hz和0~20Hz。低雷诺数下流体运动随机性频繁,Re=3660时存在32Hz,25Hz,7Hz和5Hz等多个频率集中分布段,而Re=18300和Re=25620时频率范围为0~8Hz和0~3Hz。随着测量位置z/H增加,0~1Hz内低频能量比例先减小然后增加再减少;z/H=0.85时受到自由液面的影响,集中能量频率分布范围较其他轴向位置要广,且0~5Hz低频能量比例减少。

Abstract

In order to investigate the instantaneous flow characteristics in the jet mixing zones of a circulating jet tank (CJT), a dynamic data acquisition system was employed to measure the instantaneous pressure fluctuation signals (PFS) in the Reynolds number (Re) range 3660-32940, at different axial, radial and circumferential positions. Frequency spectra were evaluated based on the local wave decomposition. The fluctuation energy distribution of instantaneous PFS was found to decrease markedly with increasing instantaneous frequency. For positions θm= π/6 and θm = π/3 the energy distributions were in the range 0-0.25Hz, while it was in the range 0-6Hz and 0-20Hz for θm= π/4 and θm =5π/12, respectively. The degree of fluid irregularity increased at low values of Re. Four concentrated energy bands at 32Hz, 25Hz, 7Hz and below 5Hz existed for Re=3660. However the energy was distributed in the range 0-8Hz and 0-3Hz for Re=18300 and Re=25620, respectively. With increasing values of z/H, the energy ratio in the range 0-1Hz initially decreased, then increased and finally decreased again. The energy was distributed in a relatively wide frequency brand affected by the free liquid for z/H=0.85 and the energy ratio at low frequency (0-5Hz) decreased.

引用本文

导出引用
禹言芳;吴剑华;孟辉波*. 基于局域波分解的循环射流混合槽内压力脉动信号时频特性分析[J]. 北京化工大学学报(自然科学版), 2012, 39(6): 23-30
YU YanFang;WU JianHua;MENG HuiBo. Analysis of the time-frequency attributes of pressure fluctuation signals in a circulating jet tank based on local wave decomposition[J]. Journal of Beijing University of Chemical Technology, 2012, 39(6): 23-30

参考文献

[1]Yu Y F, Wu J H, Meng H B. Numerical simulation process aspects of the novel static circulating jet mixer [J]. The Canadian Journal of Chemical Engineering, 2011, 89(3): 460-468. 
[2]禹言芳, 吴剑华, 孟辉波. 新型循环射流混合器湍流特性分析[J]. 过程工程学报, 2011, 11(1): 1-8. 
Yu Y F, Wu J H, Meng H B. Turbulent characteristics 〖JP3〗of a novel circulating jet mixer [J]. The Chinese Journal of Process Engineering, 2011, 11(1): 1-8. (in Chinese) 
[3]Yu Y F, Liu X R, Wu J H, et al. Comparison among turbulence models for a novel static circulating jet mixer [J]. Applied Mechanics and Materials, 2010, 26-28: 382-385. 
[4]Zhang W H, Li X G. Origin of pressure fluctuations in an internalloop airlift reactor and its application in flow regime detection [J]. Chemical Engineering Science, 2009, 64(5): 1009-1018. 
[5]Ghasemi F, Ommen J R V, Sahimi M. Analysis of pressure fluctuations in fluidized beds. Ⅰ. Similarities with turbulent flow [J]. Chemical Engineering Science, 2011, 66(12): 2627-2636. 
[6]高建强, 姜华伟, 夏豹, 等. 鼓泡流化床风帽压力信号的频谱分析[J]. 动力工程学报, 2011, 31(5): 336-341. 
Gao J Q, Jiang H W, Xia B, et al. Frequency spectrum analysis on pressure signals of wind caps in a bubbling fluidized bed [J]. Journal of Chinese Society of Power Engineering, 2011, 31(5): 336-341. (in Chinese)
[7]段锋, 黄亚继, 李斌, 等. 基于小波模极大值的湍动流态化流型转变特性研究[J]. 中国电机工程学报, 2011, 31(26): 71-75. 
Duan F, Huang Y J, Li B, et al. Flow pattern transition characteristic study of turbulent fluidization based on wavelet modulus maxima method [J]. Proceedings of the CSEE, 2011, 31(26): 71-75. (in Chinese)
[8]张建伟, 伍沅, 舒安庆, 等. 浸没循环撞击流反应器的压力脉动特性[J]. 化工学报, 2005, 56(2): 266-269. 
Zhang J W, Wu Y, Shu A Q, et al. Characteristics of pressure fluctuation in submerged circulative impinging stream reactor [J]. Journal of Chemical Industry and Engineering (China), 2005, 56(2): 266-269. (in Chinese)
[9]戴干策, 陈敏恒. 化工流体力学[M]. 2版. 北京: 化学工业出版社, 2005. 
Dai G C, Chen M H. Chemical fluid mechanics[M]. 2nd Ed. Beijing: Chemistry Industry Press, 2005. (in Chinese)
[10]Ronald N B. The Fourier transform and its applications [M]. 3rd Ed. New York: McGraw-Hill, 2000. 
[11]葛哲学, 陈仲生. Matlab时频分析技术及其应用[M]. 北京: 人民邮电出版社, 2006. 
Ge Z X, Chen Z S. Time frequency analysis and application using Matlab [M]. Beijing: Post & Telecom Press, 2006. (in Chinese)
[12]Qian S, Chen D. Joint timefrequency analysis: Method and application [M]. New Jersey: Prentice Hall, 1996. 
[13]马孝江, 王凤利, 蔡悦, 等. 局域波时频分布在转子系统早期故障诊断中的应用研究[J]. 中国电机工程学报, 2004, 24(3): 161-164, 168. 
Ma X J, Wang F L, Cai Y, et al. Application of local wave time-frequency distribution to early faults diagnosis of rotor system [J]. Proceedings of the CSEE, 2004, 24(3): 161-164, 168. (in Chinese)
[14]王凤利, 赵德有. 基于提升小波和局域波的故障特征提取[J]. 仪器仪表学报, 2010, 31(4): 789-793. 
Wang F L, Zhao D Y. Fault feature extraction based on lifting wavelet and local wave [J]. Chinese Journal of Scientific Instrument, 2010, 31(4): 789-793. (in Chinese)
[15]栗然, 陆凤怡, 徐宏锐, 等. 基于局域波与近似熵的负荷分析方法[J]. 中国电机工程学报, 2010, 30(25): 51-58. 
Li R, Lu F Y, Xu H R, et al. Novel approach for load analysis based on local wave and approximate entropy [J]. Proceedings of the CSEE, 2010, 30(25): 51-58. (in Chinese)
[16]Lin L, Zhao D Y. Local wave applied to detect and characterize acoustic emission signals [J]. Journal of Ship Mechanics, 2011, 15(6): 669-677. 
[17]刘沛清. 自由紊动射流理论[M]. 北京: 北京航空航天大学出版社, 2008. 
Liu P Q. The theory of turbulent free jets [M]. Beijing: Beijing University of Aeronautics and Astronautics Press, 2008. (in Chinese)
[18]Meng H B, Liu Z Q, Yu Y F, et al. Intrinsic mode entropy analysis of tube wall pressure fluctuation signals in the Kenics Static Mixer [J]. International Journal of Chemical Reactor Engineering, 2011, 9(A70): 1-19. 
[19]Meng H B, Liu Z Q, Yu Y F, et al. Time-frequency analysis of Hilbert spectrum of pressure fluctuation time series in Kenics Static Mixer based on empirical mode decomposition [J]. Brazilian Journal of Chemical Engineering, 2012, 29(1): 167-182.
PDF(1663 KB)

2755

Accesses

0

Citation

Detail

段落导航
相关文章

/