用绿氧（GO）与NaOH组合对玉米秸秆进行预处理，研究了不同GO添加量对玉米秸厌氧消化产
气性能的影响。结果表明：绿氧与NaOH组合预处理可使产气高峰提前，在2% NaOH中分别添
加0.05%GO（1#）和0.1%GO（2#）的预处理样品T80时间为31d和34d，比2%NaOH预处理样品（3#）分别缩短了5d和2d；总产气量较3#样品都有明显的提高，其中1#样品总产气量为40750mL，是3#样品的1.1倍；其反应后总固体（TS）、挥发性固体（VS）减少的也最多，分别由328%和478%提高到了37%和509%。因此，绿氧（GO）与NaOH组合可以提高秸秆的可生物降解性和发酵产气率。
Abstract
Green oxygen (GO) and NaOH have been used in combination to treat corn stalk. The biogasification performance of corn stalk pretreated by different amounts of GO and NaOH was investigated. The results showed that the gas production peak appeared earlier for the treated corn stalk. Values of the technical digestion timeT80(the time to reach 80% of the maximal production) were 31 days and 34days for the corn stalks treated by 0.05%GO+2%NaOH (1#) and 0.1%GO+2%NaOH (2#),respectively; these are 5 days and 2 days shorter, respectively than the corresponding values for the corn stalk treated by 2%NaOH alone (3#). The total biogas production of samples 1# and 2# showed an obvious increase compared with that for sample 3#. Sample 1# afforded a total biogas production of 40750mL, which was 1.1 times that of sample 3#. Sample 1# also showed the biggest reductions in total solids (TS) and volatile solids (VS), with the reductions of VS and TS being increased from 47.8% and 32.8% for sample 3# to 50.9% and 37.0%, respectively, for sample 1#. The results suggest that pretreatment by a combination of GO and NaOH is an effective method to improve the biodegradability and gas production rate of corn stalk.
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
［1］Luo Q M, Li X J, Zhu B N, et al. Anaerobic biogasification of NaOH-treated corn stalk［J］. Transactions of CSAE, 2005, 21(2): 111-115.
［2］Zheng M X, Li X J, Li L Q, et al. Enhancing anaerobic biogasification of corn stover through wet state NaOH pretreatment［J］. Bioresource Technology, 2009, 100: 5140-〖JP〗5145.
［3］李秀金， 郑明霞， 李来庆， 等. 氢氧化钠湿式固态常温处理提高玉米秸生物气产量的方法： 中国， 200810224492.7［P］. 2008-10-17.
Li X J, Zheng M X, Li L Q, et al. The method of enhancing anaerobic biogasificat
ion of corn stover through wet solidstate NaOH pretreatment: CN, 200810224492.7［P］. 2008-10-17. (in Chinese)
［4］万小红， 陈克利. 蒸煮添加剂在碱法制浆中的研究应用进展［J］. 江苏造纸， 2007， 3： 5-12.
Wan X H, Chen K L. Application and research development of cooking additive in s
oda pulping process［J］. Jiangsu Pulp and Paper, 2007, 3: 5-12. (in Chinese)
［5］冯改灵， 朱雁， 谢青， 等. 绿氧助剂在麦草碱法蒸煮工艺中应用的初步探讨［J］. 平原大学学报， 2002， 19（2）： 16-17.
Feng G L, Zhu Y, Xie Q, et al. Applied explored of green oxygen auxiliavies in t
echnology of braising with basic straw［J］. Journal of Pingyuan University, 200
2, 19(2): 16-17. (in Chinese)
［6］任涛， 林素琼， 刘书钗. 用棉短绒烧碱绿氧法抄造卫生纸的研究［J］. 西南造纸， 2004， 33（4）： 16-17.
Ren T, Lin S Q, Liu S C. The study on producing toilet paper in sodagreen oxyg
en pulping process with cotton linter［J］. South West Pulp and Paper, 2004, 33(
4): 16-17. (in Chinese
［7］邱玉桂， 王洪涛， 张莉. 亚铵：绿氧法蔗渣浆的氧气漂白［J］. 造纸化学品， 1999（2）： 12-15.
Qiu Y G, Wang H T, Zhang L. Oxygen bleaching of bagasse by ammonium: green oxygen［J］. Paper Chemicals, 1999(2): 12-15. (in Chinese)
［8］Zhang R H, Zhang Z Q. Biogasification of rice straw with an anaerobic-phased solids digester system［J］. Bioresource Technology, 1999, 68(3): 235-
245.
［9］牛华. 绿氧［J］. 国际造纸， 1998， 17(2/3)： 47.
Niu H. Green oxygen［J］. World Pulp and Paper, 1998, 17(2/3): 47. (in Chinese)
［10］李正国， 胡志琼， 王蓉， 等. 芦苇绿氧——烧碱法制浆工艺研究［J］.中华纸业， 1999， 3： 65-66.
Li Z G, Hu Z Q, Wang R, et al. Study on green oxygen-soda pulping process of reed［J］. China Pulp & Paper Industry, 1999, 3: 65-66. (in Chinese)
［11］唐珲军， 安显慧， 于钢. 绿氧在碱法阔叶木蒸煮中应用的初步探讨［J］ 造纸化学品， 2005(6)： 26-28.
Tang H J, An X H, Yu G. Application of green oxygen in alkaline pulping of hardw
oods［J］. Paper Chemicals, 2005(6): 26-28. (in Chinese)
［12］〖ZK(〗罗庆明. 作物秸秆高效厌氧生物气化技术研究［D］. 北京： 北京化工大
学化学工程学院， 2005.
Luo Q M. Highefficiency anaerobic biogasification of corn stalk［D］. Beijing:
College of Chemical Engineering, Beijing University of Chemical Technology, 200
5. (in Chinese)
{{custom_fnGroup.title_cn}}
脚注
{{custom_fn.content}}
PDF(921 KB)
